Home  /  News

What is the Impact of the Glass Door Cold Room Power Failure?

Sep. 06, 2019

First, frequent power outages can cause some damage to the Glass Door Cold Room at the next startup.

1. Frequent power failures are very harmful to the freezer. When the freezer suddenly shuts down during normal operation, it takes at least 5 minutes to open, which affects the life of the compressor.

2. The freezer is not a problem in the non-working state, but if the compressor is suddenly turned off and then energized immediately since the pressure difference between the two ends of the compressor is very large, the refrigerator does not work, so the thermal protection stops. If the freezing protection zone is damaged, the engine may be burned out.

Secondly, the long-term parking of the freezer should pay attention to these tasks.

1. If the energy is not energized for a long time, the refrigerant will change from a gaseous state to a liquid state during operation, which may cause damage to the pipeline and cause leakage. The effect will be very bad in the next cooling.

2. Allow the Blast Cold Room to better extend its service life. The most important thing is not to let the commercial freezer close frequently.

3. When using the freezer again, perform the corresponding inspection and cleaning work.


Glass Door Cold Room

Glass Door Cold Room

If the freezer is re-enabled after a long period of time, what is the danger, what should be noted and how to fix and solve the problem? It is dangerous after long-term suspension.

1. Long-term deactivation of the freezer will cause the lubricant in the compressor to sink to the bottom and all the workpieces in the machine will dry. At this point, if it is open, the compressor piston will operate without lubrication, which will affect the life of the compressor. This will cause economic losses.

2. How to start the long-term decommissioning of the freezer

When restarting the freezer or refrigerator after a long period of inactivity, it takes three instant starts. The specific method is: connect the power supply and then disconnect, repeat every 5 minutes, open and close 3 times.

3. Advice for Chiller Cold Storage

If you notice unusual noise or shut down after the initial start-up, if you are unable to recover from refrigeration or leaks, you should ask a professional from a regular company for repairs. Do not disassemble and repair it yourself to avoid expanding the scope of the fault.